Pianos consistently make movers annual list of products that are most often harmed. Grand pianos are specifically troublesome. Practicing the following treatments for taking apart, cushioning and filling grand pianos will prevent damage, lower claims expenditure, and improve consumer complete satisfaction.
1) A minimum of three individuals are needed to deal with a baby grand piano. If the infant grand piano requires to go up or down stairs or if a full or concert grand piano needs to be carried, a minimum of four people are required.
2) Constantly finish a thorough and accurate stock. It may be more effective or necessary to use a visual inventory to effectively explain and show pre-existing damage.
3) As various parts are taken apart, please location all hardware in a properly labeled parts bag and then put the parts bag in a "Components Box".
4) Get rid of the music rack (lyre) from its track by pulling it towards the keyboard. Wrap it in a tidy furnishings pad.
5) Disconnect the lid by getting rid of the hinge pins. Wrap the cover in a tidy furnishings pad.
6) Eliminate the prop that holds the lid open and cover it in a tidy furniture pad. The prop has a hinge pin and remains in two pieces.
7) Get rid of the pedal assembly and cover it in a tidy furniture pad. When getting rid of the screws, please be careful not to drop the braces. As you face the piano, number the push-rods from left to right as "1", "2", and "3", by positioning a piece of masking tape with the appropriate number on each rod.
8) Pad the piano by placing a tidy rolled furnishings pad (stretch-wrap the pad to avoid it from unrolling) on the cover of the keyboard to avoid it from tumbling open while you handle the piano. Note: Please ensure that the surface of the piano is dust-free before padding it.
9) Position a piano board and attach the straps so that it is ready to get the piano. The raised brace on the piano board need to be at the keyboard end of the piano.
10) Eliminate the left front leg by placing one person below the piano at the left end of the keyboard. Be sure to have two people raising the corner of the piano while the 3rd person eliminates the leg. Keep in mind: Please be sure to note which legs were eliminated from which positions since some pianos have legs that are not interchangeable.
11) Location the piano on the piano board by reducing the "leg-less" end onto the board. Please be sure to lift the entire piano somewhat while completing this maneuver to avoid excessive pressure on the staying, connected legs as the piano ideas. Be sure that the piano is focused snugly against the brace at the end of the piano board.
12) Remove the 2 remaining legs and wrap them in clean furnishings pads. These legs are kept in place by a "key and slot" arrangement. To get rid of the leg, slide it inward towards the center of the piano up until it comes out of the slot.
13) Secure the piano to the piano board by bringing the ends of the straps together and his explanation fastening them. Location folded burlap pads over the furniture pads however under the straps to supply additional protection to the edges of the piano. To avoid the strap near the narrow end of the piano from slipping off, tie the loose ends of the 2 straps together.
14) To move the piano over a flat, level surface, tilt the piano and piano board and location a four-wheel dolly under the center of the piano board.
15) To move the piano up or down stairs, use the piano board as a skid. After adequately padding the stairs for security against home damage, place the keyboard end of the piano towards the bottom of the stairs. Connect a bulge strap to the top end of the piano board to avoid the piano from slipping.
16) To load the piano, leave it on the piano board and location it in a tier as the very first base item with the keyboard dealing with the wall of the preceding tier. The very best location to pack the padded cover is in between the piano and the preceding tier or between the wall and the piano.
Grand pianos represent a considerable obstacle, they can be moved without damage by using common sense and practicing the treatments noted above.